Product ID:TONER TN51
MSDS Date:05/26/1989
FSC:6850
NIIN:01-240-2345
MSDS Number: BLWFH

CALCOMP

2411 WEST LA PALMA AVE
ANAHEIM, CA 92803
US

Emergency Phone: 714-821-2172

Info Phone: 714-821-2290

Preparer: DAVE GOLD

Cage: IO122

CALIFORNIA COMPUTER PRODUCTS SUB OF SANDERS ASSOC

3250 ANAHEIM, CA 92803 US

Telephone: 714-821-2290

Cage: 14668

HYDROTREATED HEAVY NAPHTHA; (ALIPHATIC HYDROCARBON)

CAS: 64742-48-9

Fraction By Weight: 99.6%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 0.4%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ENVIRONMENTAL CONTROL AGENCY FOR ASST. POSSIBLE

RTECS: 9999999ZZ

AS PARTS CLEANING SOLVENTS. RECYCLED MATERIALS

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:(ACUTE & CHRONIC) SKIN: CAN CAUSE
DRYING OF SKIN OR IRRIT. EYES: CONTACT MAY CAUSE IRRITATION. INHAL:
INHAL OF VAPORS MAY CAUSE HEADACHES AND DIZZINESS. INGEST: PRODUCT
HAS LOW ORDER OF ACUTE ORAL & D ERMAL TOXICITY, BUT IF ASPIRATED IN
LUNGS DURING INGEST/VOMIT, MAY CAUSE MILD TO SEVERE PULM INJURY &
POSSIBLY DEATH.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HIGH VAP CONC (>1000 PPM) ARE IRRIT TO EYES &
RESP TRACT, MAY CAUSE HDCH & DIZZ, ARE ANESTHETIC, AND MAY HAVE
OTHER CNS EFFECTS. DEATH IS POSSIBLE IF EXPSD TO VERY HIGH CONC FOR
PRLNGD PERIODS. PERSON S SENSITIVE TO HYDROCARBON EXPOS MAY
EXPERIENCE DISCOMFORT WHEN EXPSD TO CONC BELOW ESTABLISHED SAFE
EXPOS LIMIT.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.

First Aid:EYE:FLUSH W/CLEAR WATER FOR AT LEAST 15 MIN/ UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL MD. SKIN:REMOVE CONTAM CLTHG.
WASH SKIN THORO W/SOAP & WATER. DO NOT REUSE CONTAM CLTHG UNTIL
SOLV HAVE BEEN REMOVED. INHAL:REMOVE VICTIM TO FRESH AIR. CALL MD
IMMED. IF BRTHG IRREGULAR/STOPS, START RESUSCITATION IF TRAINED.
ADMINISTER OXYGEN IF AVAIL. INGEST: DILUTE CONTENTS OF STOM
W/SEVERAL (SUPP DATA)

Flash Point Method:TCC
Flash Point:> 102F,39C
Lower Limits:1.0%
Upper Limits:6.5%
Extinguishing Media:FOAM, DRY CHEMICAL, OR CO2. USE WATER SPRAY (FOG)
TO COOL FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NORMAL PROCEDURE FOR COMBUSTIBLE LIQUIDS.
Unusual Fire/Explosion Hazard:KEEP PROD AWAY FROM SOURCES OF IGNIT SUCH
AS HEAT, SPARKS, PILOT LIGHTS, STATIC ELEC, ELEC APPLIANCES & OPEN
FLAMES. AVOID EXTING W/WATER-IT TENDS (SUPP DATA)

Spill Release Procedures:ELIM ALL IGNIT SOURCES. RECOVER FREE PROD BY
ADDING SAND, EARTH/OTHER SUITABLE ABSORB TO SPILLED LIQ. KEEP
NON-ESSENTIAL PERS AWAY. AVOID BRTHG VAP. VENT CONFINED SPACES.
CLEAN-UP ABSORB MATL & DISPOS E OF PROPERLY. CONTINUE TO OBSERVE
PREC(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EMPTY CONTAINERS RETAIN RESIDUE
(LIQUID AND/ OR VAPOR) AND CAN BE DANGEROUS. DISPOSE OF PROPERLY.
Other Precautions:KEEP CNTNRS CLOSED WHEN NOT IN USE. DO NOT SMOKE WHEN
USING PRODUCT. MINIMIZE BRTHG VAP/MIST. USE WITH ADEQ VENT. AVOID
PRLNGD/ RPTD SKIN CONT.

Respiratory Protection:NOT NEEDED WHEN USED AS INTENDED W/CALCOMP
PRODS. IN CONC EXCEEDING RECOMMENDED SAFE EXPOS LIMIT, SUCH AS
DURING A MAJOR SPILL, USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESP EFFECTIVE FOR ORGANIC VA PORS.
Ventilation:SUFFICIENT TO PREVENT EXCEEDING EXPOSURE LIMITS.
Protective Gloves:NITRILE OR NEOPRENE.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:CHEMICAL RESISTANT APRON WHEN CLEANING
MACHINES AS REPLENISHERS MAY STAIN CLOTHING.
Work Hygienic Practices:WHENEVER HANDLING CHEMICALS, ALWAYS USE GOOD
PERSONAL HYGIENE PRACTICES, SUCH AS WASHING YOUR HANDS AFTER DONE.
Supplemental Safety and Health
EXPLO HAZ:SPREAD HYDROCARBON SOLVENT FIRES. FIRST AID PROC:GLASSES OF
WATER. DO NOT INDUCE VOMITING. CALL MD IMMEDIATELY. SPILL PROC:FOR
VOLATILE, COMBUST VAPS FROM ABSORBED MATL. THERE IS NO REPORTAB LE
QTY (RQ) UNDER CERCLA REPORTING REQ.WASTE DISP METH:PETRO BASED
OILS. CONT LICENSED HAZ WASTE DISP CO OR (SEE ING 3)

HCC:N1
Boiling Pt:B.P. Text:>350F,177C
Vapor Pres:34 @ 25C
Vapor Density:5.3
Spec Gravity:0.76
pH:NEUTR
Evaporation Rate & Reference:0.45 (BU AC=1)
Solubility in Water:NEGLIGIBLE; 0.1%
Appearance and Odor:BLACK LIQUID. FAINT PETROLEUM HYDROCARBON ODOR.
Percent Volatiles by Volume:99@77F

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQ CHLORINE, CONC OXYGEN, AND SODIUM HYPOCHLORITE
OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:SMOKE, CO, ALDEHYDES, & OTHER DECOMP
PRODS WHICH MAY OCCUR IN EVENT OF INCOMPLETE COMBUSTION.

Waste Disposal Methods:RCRA HAZ WASTE NO. - D001. WASTE TONERS &
REPLENISHERS ARE HAZ WASTES AS DEFINED BY 40 CFR CHAPTER 1. ASSURE
CONFORMITY W/ALL APPLIC FED, ST & LOC DISP REGS. WASTE TONERS &
REPLENISHERS ARE COMPAT FOR DISP W/MOST NON-HALOGENATED SOLV &
(SUPP DATA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.